1G (1998-2000) S70, V70 & V70XC Forum -

Evaperator Replacement:
First thing you have to do is disconnect the battery.
Next you will need to remove all the freon.
Next start off by removing the wiper arms.There is a 13mm nut per arm.You may need to remove a black cover to get to the nut.
Then remove the 4 Torxes 25 screws holding the plastic cover under the the wiper arms.You will have to also remove the 2 clamps...

I made this tool at work to check for intake leaks and leaks in the vent system.
Some people will by Fog machines in shops that will do almost the same thing.
This is only a picture of the tool and a small idea of how to use it.
This can only be used with a air compressor.

So I got the round plastic cap looking thing from a New fresh air hose that was purchased from the...

These are Volvo instructions.
Remove
The oil dipstick and its pipe.
The splashguard under the engine.

Drain the oil and remove the oil filter.
Release the oil cooler from the sump.Hang up at the rear.
Remove the screw from the bracket for the fuel line.

Removing the oil sump(oil pan)

Slacken off all screwsholding the oil sump.

Hi ,this is my first question to the forum
I have an '99 v70 xc awd with 135000 miles.
after an 160 mile daily trip I was traveling cruise control 60 mph when a very slight vibration started not continuous but rhythmical and it got stronger,when I pulled off the expressway and into a gas station this noise came from the front as if you stick a metal wire into the blades of a fan,when...

Wanted to know

1. where can I get a used or rebuilt turbo for a 98 s70 GLT.

I havent looked at the car yet but he said its spitting oil all over. I dont really know if the seals are ok to replace or if they fired the internals and everything else, trying to keep it easy and quick for him. Its still spooling but blowing oil so Im thinking I might be able to bust it down...

Does anyone know if a 1999 volvo v70 will continue to run once the vehicle is cranked on the alternator once you have taken the battery out of the circuit?

After scouring these boards for possible reasons to ABS problems, I removed the ABS module to have it reconditioned. I've read that the brakes will work fine without the module (and they do...a bit "squishy", though) but I was surprised that my speedo/odo stopped working. I know that speedo malfunctions are also a sign of ABS module failure, but didn't expect total speedo...

Hello, this is my first post and unfortunately, i'm asking for help.
I've just bought my first Volvo - a 1998 S70. I'm very impressed and happy with the car but it has a fault with the courtesy light in that it doesn't turn itself off when either the doors are closed or the engine is started?
Anyone with any ideas?
Cheers

Hello all, this is my first post on here, just found the site on a google search.

I'm in the unfortunate position of having damaged beyond repair my 850 manual estate.

I've been looking through the "auto trader" ads in the UK at the 2.5 litre diesel powered V70's as a possible replacement.

Many of these cars have the automatic gearboxes,...

Hi there, I'm so pleased to have found you...

Has anyone else fitted 18" Volvo Nebula alloys on to a Phase 1 V70 before? My standard Perfo's were looking scruffy, and having looked on VPCUK.org it seemed that they could be fitted, so a few hours and few hundred pounds later on ebay I had bought a set default/' ...

i recently installed a gauge and my take on it is that its just a piece of crap default/thumbsup.gif' 'thumbsup.gif' /> . the needle points to 10 psi vac when power off, and the power lines dont zero it (they only light the assembly). i hooked it up to both the vac line (bypass) and the...

Hi-
I have a 2000 S70. The A/C blows cool until the car idles, then it blows hot air that smells musty. Do I just need freon or could it be something else? I haven't specifically asked for freon to be checked with tune-ups. Is that something I should specifically ask for or is it something automatically part of tune-up? NOTE: I do not take the car to dealership for repair as it is out...

I have a 2000 S70 GLT that has an idle problem. When in park the idle fluctuates from around 500 RPM to 1000 constantly. It oscillates between 500 and 1000 PRM around every 2 seconds or so in an almost rhythmic manner. When driving the idle is around 800 and fairly constant although sometimes will oscillate between 750 and 850. Also sometimes when I come to a stop the idle will get real low...

Hi all, I am a newbie just found your site, I have a 1998 Volvo V70 AWD, Turbo with just over 106,000 kilometeres
(Canada) and a strange warning light came on its orange with green triangle in the middle I assume is a check engine light, its not listed anywhere in my manual.

The other strange thing is the car had a very loud fan blowing noise when I shut the car off for about 3...

My 98 V70 has 100,000 kilometeres and its also a Turbo

When should I get a tune up, it has never had one?

Thanks

sorry as a woman I really dont know much about cars and hate asking dealers or garages.

Cheers default/liebe011.gif' 'liebe011.gif' />

This is what I have read from another volvo owner,

I got the ignition locked changed. It took a week to get the lock and one false start when I discovered I would need a long T30 socket to get the airbag off. The short socket will not fit and I couldn’t get enough leverage with the T30 screwdriver. The VADIS highly discourages stripping those bolts and I agree, I would...

Hi Everyone

This is my 1st post

I have a 97 T5 V70 estate which I am sorting out.

One of the problems ias the lack of variable wiper delay

I can get the Ipdusa Smart relay (see attached pdf) for $38 but they want an extra $65 for shipping. Is it available in the UK or is there some other kit ?

Any help would be appreciated

I have an S70 GLT. It hs new plugs, wires, distributor cap and rotor. I have replaced the Fuel injectors and the Mass Air Flow Sensor. I still get what feels like a plug misfire. The check engine light is not on.

default/00000732.gif' '00000732.gif' />

Hello all

CABIN AIRFILTER ? ......

I have seen a post somewhere here in relation to the Cabin Filter but there were No Replys .............................

(1) Where is this Filter located ?
(2) How...

I Have been starting to have problems with my S70/SE when it downshifts into the lower gears. The shifting is rather ruff and abrupt at times. Seems it only does this when it is warm. Can anyone advise me what this may mean.

Regards
Miller

I am planning on installing a manual boost controller on my 98 v70 XC, my questions are: does my car have an intake plenum?, where would the hose come from (where exactly on the wastegate) for installing the control?, do the sport and economy modes act as variable control (i found what was basically a bleed off coming from the wastegate and splitting into two hoses, one that went to the...

So my car gets up to normal running temperature and stays for about 5 minutes of driving. Then within about a minute it goes up to just below the red lines on the temp gauge. It stays there for about 5 minutes and then goes back down to normal. After that, every minute it goes up then down again.

I changed the thermostat thinking maybe iot was just sticking but no luck there. I...

Has any here removed the head on a 2.4l turbo on a s70 glt ? how much labor is involved? also what kind of money we talking to rebuild the head, gaskets ect.

I recently found out #2 cyl has no compression, did a wet test , still same thing. what type of manual is the best to have, the haynes and chiltons are to general. anything else you guys use. i have 134k on it . runs like champ...

Hi everyone,

I have a 98 V70 T5 that has a strange problem !

It seems to have a form of vapor or mist coming from the air vents at times, this could be at any time but seems to happen more perhaps when the air con is first turned on.

It doesn't do this all the time, and the air con works very well indeed, so I have ruled out the fact that it could be...

1998 V70 - My battery has been tested and is good, but if the car is left parked for a few days, the battery goes dead. I can recharge and it works as long as I drive regularly. there are no lights on. Any idea how to trace this issue?

Hello everyone! I am a new member; I just purchased a '98 v70, and decided I may as well start lurking here to see what I can learn about my new car.

This is my first volvo (I have been a big subaru fan, but the deal was good), so I hope it treats me right! Anyway, Just wanted to say "hi," and thanks to everyone for helping to build this forum for people like...

I have a little oil leak from a pipe(been told it is a turbo related pipe),as you look down over the radiator its the top pipe to the left.Anyhow it has a very slight leak and need to know is this an easy replacement for me to do or does my car need to be garaged.
How much are these pipes.
Thanks.

Hi to you all

I joined this site in the hope that someone might be able to help me fingers crossed.
I have a volvo 1998 2.5 turbo cd (low compression) and the car just keeps cutting out after a miles or so. It re-starts ok and might not cut out for a while then.
The engine man. light is not on.
I've cleaned the throttle body and idle valve and even put a second hand...

I am thinking of buying another Volvo - There is a 1998 Volvo S70 Turbo for sale in my area for around 6 - I was gonna offer around 5 or 5500. She has 95K miles...

Any opinions?

Heather

We have a 1998 Volvo V70 XC AWD and the check engine light code reads 455. What does this mean? Any direction would be appreciated…thanks.

I am looking to purchase an OBD II connector and software for my 99 V70 TD.

Engine management light has come on and the battery has flattened after 6 days of now use.

Can anyone in the UK reccomend any to buy which work properly.

Many thanks

default/00000732.gif' '00000732.gif' /> Hello Members

I have recently bought this Volvo v70 1998 2.5 lpt Turbo with 93k (fvsh)

The Noise difficult to describe but it doesnt sound like when the brake pads are low
The handling of the car the way it sits on the...

Hello Group, I just recently purchased this 99 v70 xc awd for my wife Marcia, and the trans fluid doesn't have that new look or smell. Trans works fine, but I wanted to flush & replace filter. Mechanic here says he can not find anything about a filter. Does anyone know more? Thanks. Jim

This seems to be a common issue - the hood release from the car interior won't release the hood. If I have someone in the vehicle pulling the release, I can then pop the hood, but if I pull the release, then go out to pop the hood, no dice. Because of the scenario -it leads me to think that the spriings need some attention (if there are any) - shouldn't they pop the hood slightly up when...

Hi

I've got a '98 V70. Fuse no. 6 (Siren alarm and lock) (20amp) keeps blowing every so often. This immobilises the vehicle (normally leaving my wife stranded somewhere). I change the fuse and everything works again and the car will start.

Any ideas on what could be causing it?

Thanks

Phil.

OBD on my 99 S80 T6 revealed code P1132 after check engine light came on. I have read in some places that there are 4 O2 sensors (2 front and 2 rear).

If that is true, do I need to change both front O2 sensors for this code?

Hey all, I've seen a nice looking 2000 xc70 for sale on my way to work. I have yet to stop in to have a look, but am feeling the urge!!! I'm currently in an 87 240 and needless to say the xc70 is a bit different to say the least.

I'm wondering if some of you could give me a bit of a review, what to look for, $$$ value etc. on this car. It...

i've just owned rear wheel drives but am considering a front wheel or all wheel drive. Some posts are disturbing about the gear tronic transmission, and other repairs which have to be made. Has the reliability been reduced on the 70 models compared to the older rear wheel drives?

Are there years or models to avoid for the Volvo V70 or XC70, or should one just but a Honda CRV or...

Hi, I just registered to this forum and as of late have been more and more into VOLVOS. I'm a VW technician at a dealership but now I'm working on my Landlord's V70 (98) 2.4 turbo. He is losing oil in several spots. What I'm trying to determine is if the valve stem seals and/or turbo are burning/leaking oil. Down inside the turbo it is very dry except for around the rubber...

I have a '98 V70 that needs some help.....The rear hatch will not open from the outside of the vehicle. When you pull the handle it moves a bit, but it requires the interior handle to pushed down. I tried to remove the interior panel, but could not get it off the handle. Do I need to remove the handle and slide the panel off? Any help would be appreciated! My pregnant wife can't crawl...

I have a 1999 XC70 2.4 T5 AWD with 105,000 miles. Last summer, the car's first in Texas, I experienced a weird problem after getting an oil change. The mechanic used 5W 30 in the car. After doing this, the oil light would come on when the car was hot (run for 20 minutes plus at highway speed) and the brakes were applied. The sequence was apply brakes, RPMs drop to just below 800, light...

Hi Everyone.
Can anyone tell me where is the "Air Mass Meter" located on my 1997 2.5 10v V70? What numbers should I look for to find the correct replacement?
Any help greatly appreciated default/liebe011.gif' 'liebe011.gif' />

Hi-
I have a 2000 S70. The A/C blows cold until the car idles then it starts blowing hot air and it smells musty. Does it just need freon or is there something else wrong?

Thanks in advance for your responses and advice!

PRD

Hello everyone,

Does anyone know how to replace a light in a '98 S70 T5 radio ?

Half of the radio is now dark.

I spoke to a mechanic and he stated to buy a new one. It would be easier.

This seemed alittle extreme.

Any ideas?

Regards,

Brendan

Hello folks,

My '98 S70 T5's autolock will lock all 4 doors but only opens 3.

The rear passenger button needs to be manually pulled up.

By the way, it's got 268K + miles and still going strong.

Thanks !

Brendan

Hi Folks,

New member here with an annoying problem!

Symptoms are, the car cranks over, fires and then dies - it appears to die faster if you gently touch the throttle, as one normally would. It's been doing it a while. The revs rise when I first start it, then fall, and if it's going to stay running, they fall to idle, but if its going to die, they just fall to...

Can any of you kind people help me out with a few queries please?

My recently acquired (ie yesterday)'97 V70 2.5T CD Auto Estate has a couple of snags.

1) The r/h/s headlamp wiper sweeps up until almost vertical (ie. I can see the blade while I operate the washers whilst sitting in the car). Clearly it's over moving, but seems to park OK when finished. Is there any...

I recently joined the list of proud Volvo owners and purchased a pristine 1998 S70 T5. I would like your opinions and advice as to brake rotors and pads. I am looking to repalce the front and rear rotors and pads soon and would like some input on different brands and styles. Do you suggest cross drilled and slotted versus just slotted if so why? What brand rotors are you guys running and the...

had clicking noise coming from the rear. remove the caliper and find that the parking brake shoe was off. actually it is the brake material not the steel shoe. can i use adhesive to re-seat or must i replace the entire shoe?