2G (2001-2007) V70, V70XC & XC70 Forum -

Brake Booster replacement:

First start by Disconnecting the Battery.

Then open the hood and remove the Upper torque mount cross member.

Next remove the Air filter housing.

The remove the Big Cover over the Relay/fuse panel under the hood.
Once the cover is off remove the 13mm nut for the Positive cable.

Then remove the 2 screws...

I have a 2002 FWD V70. I need advice about how to access the Parking Brake adjustment. screw I have found instructions for other Volvo Models but I have not found anything for mine. There does not seem to be an obvious way to access the adjuster and I don't want to break any plastic with random prying.

Any advice would be greatly appreciated.

Hi to all,
I have owned my V70 D5 s auto for approx. 6 mths, recently the amber warning triangle has come on, on the dash, the digital time display clock races forwards on ignition and the display msg comes up with a 'SRS airbag service urgently required'.
I took it to a garage and had the computer read on the vehicle and the code P0244 was indicated, the mechanic cleared this...

New member - Hi folks - with a problem of course......!!

2003 V70 D5 suddenly puts up dashboard message 'check brake lights'. I do so, neither side working, so assume its the bulbs (both at once....??) and replace. Still out. High level LED bar on tailgate working fine by the way.

Check fuses - boot fuse box no.3 and 14 intact (as identified from handbook)...

Hi, Hope someone can help. I have reclined my rear seta behind drivers seat today, when I went to put it back up the seat belt had retracted and I now cannot reatract and it is fixed tight and stuck. How can I get the seatbelt to move? so I can get the seat back up. HELP? Thank you

Anyone know if a faulty fuel pump relay will cause a no start? I tried the diagnostic and the only code I got was a 132 in socket six. Socket 2 proved no problem. The funny thing is that this all began after a high pressure car wash and ten after sitting a no start. Then after about hour and a half with hood open it started Then a small rain shower, same deal...Now no start, it's like there is...

Sometimes when I get out of my 38,000 miles 2005 XC 70 miles after driving, I can smell burnt oil coming from the engine area. I change my own oil (very fussy and enjoy it), so I see the underside of the engine without the belly pan. I can see no oil leaks nor do I leave any oil spots when parked. I keep hearing about turbo return line - need some opinions.

Still have waranty time...

Has anyone used E85 or other Ethanol blends in their V70 XC (2002 or similiar)? What, if any, conversion steps were required? Were there any problems?

With the prospect of very inexpensive alcohol fuel becoming available later this year, we're very interested in running our cars on a mixture of mostly alcohol and as little gas as possible. Thanks in advance for any help.

Can anyone tell me if the HU-803 radio (the 4 cd stack one) in a V70 03 model has a CD input at the rear as I have found an ipod adaptor in the USA that allows full control and displays albums and tracks on the ipod screen unlike the official Volvo adaptor?
Many thanks
struggs default/' ...

Hi

Ist post, so go easy.I've searched on the forums for my problem (well, the car's) and have had no joy...

1999 V70 2.4 petrol. Sluggish at low revs, although goes fine in 3rd with foot to the floor. Gives the impression that the more you push it, the slower it goes. Very kangarooish at low revs (say, from traffic lights) and it's struggling to climb up the revs...

Hi folks:

I'm new to this forum and look forward to the great info here. I just bought a 2005 xc70 and I received one key, the remote, no valet or other remote. Is there a work around for the $325 it costs to get another? I am thinking of getting a valet key made for $160...in any case, it stinks so I thought I would check to see if anyone has a workaing alternative to the...

I have a 2004 XC 70 with about 35000 miles. The vehicle has been totally trouble free but next month the factory warranty expires and I am wondering if it will fall apart the following day.

My original dealer is offering an extended warranty for 3 years 100000 miles for $3800. Is this needed?.. advisable?.. a rip off??? What are peoples experience from 35000 miles to 80000...

Hello fellow V70 drivers!

I've had problems with my car's transmission for over a year now and so far I have not found a proper solution. Today I came across this forum and it seems to be the most comprehensive source of information on various Volvo issues on the net, so perhaps somebody here has noticed a problem similar to mine and can suggest a fix.

The car is...

Greetings To All Fellow Volvo Drives,

I'm new to the forum, been driving Volvos since 77. We're on our sixth and will never switch.

My question regards cross bars. I plan to leave them on the car and wonder which would be the best type to get. Round, square, or the wing shaped. I only plan on carrying a few surfboards.

Your comments on your experience will...

I have a 2001 V70 T5 that has been sitting in a transmission shop for 1 month. They are at loss of what to do next. Rebuilt Transmission (gone over twice); rebuilt Valve Body; new Solenoids; Software upgraded. The intermittent problem is the car downshifts from 3rd to 2nd rough. It feels almost as if it misses 2nd and goes into 1st, but they see that is not the issue. Up shifts fine, and the...

Can someone please tell me where the oil filter is on a 2004 Volvo XC70. I purchased the filter (it is only a paper insert) but I cannot find where it goes on the engine.

I just purchased a 2007 V70XC that has the shopping bage storage compartment in the cargo area. Can anyone recommend a cargo mat that is flexible so that we can still use the shopping bage storage?

Hi,

I have just found my rear tailgate does not lock, I only have keys for locking no key fob and wondered if there is a common fault? I presume that is why alarm red led does not work when car is locked?
I have ordered a key fob but I think it will not work as the tailgate is open?
Are there any switches or sensors, the dash display says tailgate open when I open it and goes...

I have had a Volvo mechanic look at this and he mentioned the tailgate is locking ok. There is a problem with the sensor system for the tailgate which the Volvo tech claims will take many hours to diagnose!!!! ($$$)

Does anyone have any experience with this?

Hi Gang,

I'm a total Volvo noob. There, I said it. default/' '' />

I hope these types of posts aren't too annoying. I'm an active member on a sailing forum and can understand that noobs can be a little annoying at times. I'll try to make this...

I have a 2002 V70.
I got a pearcing squeel a few weeks ago.
I thought it must be the belt, so I replaced it.
Seemed to slack off when I did. But soon enough it got worse.
I thought maybe it's a bad pully so I pulled the belt and checked the pully.
They seemed to be fine. I had about enough and wife was pegging out the frustration meter so she took it to a mechanic this...

Well, over the past month or two, I've been experiencing some strange problems with my AC system. When I start my car, my AC works fine, but about 15-20 minutes into driving, it cuts out.... The fan is still going, but it stops blowing cold. It seems to happen, not just under constant driving, but if I'm going around running errands and stopping/starting the car often. I did find, however,...

Does anybody happen to have a diagram of the serpentine belt routing for a 01 V70 T5?

Hi all,

I have a 2003 D5 S V70 with a unusual problem. It has blown out a core plug in the casing and has blown the lower rubber turbo intake hose.

When i take the oil filler cap off it smokes like crazy and makes a popping sound. Smoke also comes out of the dip stick when i remove this.

I have taken the two hose's off the top of the Oil Breather box and...

My wife and I are about to purchase a 2001 V70 T5 M with about 105k miles on it. The car looks almost perfect on the outside and I looked it over with a mechanic today and everything seemed in good shape -- no oil leaks, etc.

A lot of people seem to think that 99-01 V70s are sub-par. It also sounds like I'll have to replace the timing belt right away, since I don't think it...

Hi All,

I have a 2003 V70 2.4 TS with 200bhp and Nebula 18" 235/40/R18 goodyear F1 tyres on.

I have just bought a 1200 kg caravan but have no idea what tyre pressures to put in these tyres.

Current driving with 2 adults, a child and dog are 30psi in front and 29 in rear.

I know the pressures for caravan tyres but wouldsomeone please tell me or point...

Hi guys, this is my first post.

I've serached for help on this, and found a couple of suggestions, but none seem to be right.

I bought a new mirror glass with the wide-angle to replace the original. Used this in Europe and it makes a world of difference, especially for my wife on the highway!

Anyway, I'm trying to remove the old glass, and it's...

I've had my 2001 V70XC for three years and have had no confidence in its reliability from day one. I bought it at 45,000 and it has 80,000 miles on it and the electrical is making me crazy.
Problems:
1. Power seats jitter and dance around and occasionally recline all the way down while driving.
2. Instrument cluster goes dead.
3. Heater occasionally goes dead.
4....

This morning when I backed out of my driveway I put my car in drive, a second later there was a clunk and at the same time my STC icon came on and the STC Service Required message came up. I hit the gas, but the car would not move, it just revved. I tried again a second later and it moved forward, but heavily and sluggishly as if it didn't want to go. I pulled off the street and turned the...

hi all,
My 2001 V70 auto came with volvo 16 inch standard fit alloy wheels, they are shod with 215/55/16 tyres, which according to VADIS is the middle size I could fit. Problem is they rub on the inner wheel arches any time I get anywhere near full lock on the steering, which is quite a problem using UK size parking spaces. I have read that this is a problem with certain aftermarket...

I've read many posts about people having problems with their fuel door hinge, however, my 2001 XC70 has no latch. As in; when I make a U-turn I can see it swinging open in my passenger side mirror. Is there supposed to be a grommet in there or something? I also read here that after 10 minutes the fuel door is locked. Not on mine. If anyone can tell me what parts I need to fix this I would...

I am wanting to replace the cabin air filter on my own, but am unsure on the location. Is it under the dash on the passenger side? I would love some guidance on this. Thanks!

hi all,
my 2001 V70 has a buzzing noise coming from behind the a/c / audio area.It starts as you sit in the drivers seat and if you don't start the engine eventually stops after about 5 mins. I am wondering if it is something to do with the motion sensor but it doesn't seem to matter whether I use the 'blipper' or the key to lock the car, as soon as I get back in the...

My V70 2001 is currently showing a much too low outdoor temperature each one of three time I turn on the engine. If I turn off the engine after a while and turns it on again, the temperature is read correctly.

I guess the outdoor temperature sensor is either dirty or is a little loose.

Does anyone know where the outdoor temperature sensor is located?

After 18 months and 11,000km the brakes on my 2006 XC70
shudder badly. Dealer has traced to heavy corrosion on rear
brake rotors, and says it is my fault as I don't drive
often enough, and the corrosion builds up, and doesn't
get removed through normal use. Not covered by
warranty, $400 for new rotors.

I haven't had this problem in 30 years of...

Car: V70
Year: 2000 (ish)
Problem: Sat Nav Changer.

Hi all,

I’m trying to help my old man out with his sat nav system. It’s a multi disk changer in the boot which holds 6 disks, currently with three in there (GB and two French disk all 1999).

When he turns the system on the screen pops up and asks for the disk to be put in, if you take the...

HI
JUST TRYING TO SOLVE A FLUTTERING WIND NOIZE ISSUE ON THE DRIVERS WINDOW , STARTS AT 45 MPH.
MY SON HAS THE SAME MODEL WITHOUT THIS PROBLEM , I HAVE COMPARED BODY WORK , TRIM ETC ETC ON BOTH AND CANT DETECT ANY OBVIOUS DIFFERENCES.
ANY IDEAS.
BEST WISHES
RUNSHAW

Have a 2005 XC-70 that I've owned about 4 months. Noticed this weekend while driving at speeds of 40+ a dragging sound from front end; a friend followed me and identified something coming down and dragging near the front tire.

My bro-in-law, a BMW tech, looked and said he saw a loose panel that obviously had 3 or 4 clips or holders missing. He couldn't tell from the side (he...

My XC70 2003 with 310,000km has ben a charm til now. At 110km car shakes
and then smooths out at 120. Dealer says tires. Tire man says alignment.
My gut says transmission. Any similar experiences.? Any recalls in this area.?

Hello Everyone,

My dad has recently bought a Volvo V70 T5 SE however it did not come with a car manual, so we don't really know what all the buttons do and where the controls for anything is and all the techie related things.

Do any of you know if there is a V70 car manual published on the web, because i have seen one for the S60 posted on the web.

Your help...

Hello there i have just recently bought a volvo V70 t5 it has got the geartronic option gearbox, the problem is that its giving me 12 mpg city driving and this is driving normally without flooring it, i have tried switching fuels and filled it up with bp unleaaded premium but it this has not made any difference whats so ever, can anyone out there help me?

Thanks!

Hello:
I have just joined this forum and have been most frustrated tonight.
My V70 was quite low on fuel so, I pulled into a gas station to fill, but the gas door wouldn't open even though I had all the doors in the Central Locking System unlocked as per the user's manual.

The attendant said he has seen this in other Volvo's.

Just got home and tried to...

My car is almost out of gas and I can't refuel it because my fuel door won't open after I push the fuel button inside the car. I don't hear the audible click when I push.

I am wondering if there are any workarounds to getting the fuel door open? Help!

This is a problem on my 2 yr old V70 bi-fuel of entire system failure whilst driving - this takes place at about 20 to 25 mph in LPG mode and causes the engine to cut out, loss of brakes and loss of powerstreering. I believe this is a very dangerous design fault in either my particular V70 or the LPG system as a whole.

I don't want to go into my history so far with Volvo on this...

Hi

I was previously a member of the forums which seemed to disappear round about April time. It was a fantastic source of info for my varios Volvos (now on third different model). Is this the same site re vamped and if it is thank god your back.
Mike
default/00000732.gif' ...

Hi

I need to replace a headlight unit on my V70. I have the replacement unit but need some advice on the procedure for swapping them over. I have looked at it today and it appears that you need to remove the bumper in order to do this.

I normally rely on Haynes manuals for instructions but they haven't produced one for this model yet! Any advice or info out of a...

Hello,
I've had a 2002 diesel XC70 (Geartronic) D5 AWD for about 6 months now. In the last week it has lost power a couple of times while driving, and a message has come up on the dashboard saying "engine service required" (it was only serviced a few weeks ago).
After about 10 seconds of no power (it doesn't cut out but just acts as if you've taken your foot off the...

Hi,
I have a 2001 V70 T5. The check Engine Light came on and it said Emission Control Service required. I bought a OBD2 Codereader and got two Messages:
P0172 ( System to rich Bank 1 ) and P1171 ( Fuel Adaption ). I have no Idea where to look. Does someone know something about those Problems?
Thank's

Thought I was only getting 5 months out of the lowbeam bulb I changed in January, but it is actually the plastic housing on the end of the wires that's shot. I used some electrical tape to hold the metal crimp at the end of the wires to the bulb, which lit the bulb and works for now. Autoparts chain 'R & S Strauss' has a universal pigtail for $4, comes with about 24 inches...

Anyone ever experienced total failure of the upper spring mount with punch through? 90,000 miles. Bilstein struts and shocks installed 12 months ago. Right front strut appears to have about an inch of free play. Still rubber to rubber contact so no noise. That said, turning corners had a sort of "heave to" feel. Control arm bushings need replacement, and I put the funny handling to...